Dito Dean D20 Manual do Utilizador

Dean, a member of the Commercial Food Equipment Service Association, recommends usingCFESA Certified Technicians.24-Hour Service Hotline 1-800-551-863

THIS PAGE INTENTIONALLY LEFT BLANK.

DECATHLON SERIES GAS FRYERS (NON-CE) CHAPTER 2: IMPORTANT INFORMATION 2-1 2.1 Receiving and Unpacking Equipment A. Check that the container is u

DECATHLON SERIES GAS FRYERS (NON-CE) CHAPTER 2: IMPORTANT INFORMATION 2-2 2.2 General (cont.) Where conflicts exist between instructions and inf

DECATHLON SERIES GAS FRYERS (NON-CE) CHAPTER 2: IMPORTANT INFORMATION 2-3 2.4 Rating Plate This is attached to the inside front door panel. Info

DECATHLON SERIES GAS FRYERS (NON-CE) CHAPTER 2: IMPORTANT INFORMATION 2-4 2.5 Pre-Installation (cont.) C. Installation Standards 1. U.S. in

DECATHLON SERIES GAS FRYERS (NON-CE) CHAPTER 2: IMPORTANT INFORMATION 2-5 2.6 Air Supply and Ventilation (cont.) D. Do not place the fryer’s fl

THIS PAGE INTENTIONALLY LEFT BLANK.

DECATHLON SERIES GAS FRYERS (NON-CE) CHAPTER 3: INSTALLATION 3-1 3.1 Installing the Fryer A. Initial Installation: If the fryer is installed with l

DECATHLON SERIES GAS FRYERS (NON-CE) CHAPTER 3: INSTALLATION 3-2 3.3 Installing Casters and Legs A. Install casters and/or legs near where the f

DECATHLON SERIES GAS FRYERS (NON-CE) CHAPTER 3: INSTALLATION 3-3 3.4 Gas Connections DANGER Before connecting new pipe to this appliance the pi

DECATHLON SERIES GAS FRYERS (NON-CE) CHAPTER 3: INSTALLATION 3-4 3.4 Gas Connections (cont.) DANGER All connections must be sealed with a join

DECATHLON SERIES GAS FRYERS (NON-CE) CHAPTER 3: INSTALLATION 3-5 3.4 Gas Connections (cont.) E. Manifold Pressure: Your local service technician

DECATHLON SERIES GAS FRYERS (NON-CE) CHAPTER 3: INSTALLATION 3-6 3.4 Gas Connections (cont.) 3. If disconnection of the restraint is necessary,

DECATHLON SERIES GAS FRYERS (NON-CE) CHAPTER 3: INSTALLATION 3-7 3.5.2 Gas Conversion Procedures DANGER This appliance was configured at the fa

DECATHLON SERIES GAS FRYERS (NON-CE) CHAPTER 3: INSTALLATION 3-8 3.6 Electrical Connections The fryer when installed must be electrically groun

DECATHLON SERIES GAS FRYERS (NON-CE) CHAPTER 4: FRYER OPERATIONS 4-1 4.1 Initial Start-up WARNING The on-site supervisor is responsible for ensu

DECATHLON SERIES GAS FRYERS (NON-CE) CHAPTER 4: FRYER OPERATIONS 4-2 4.1.1 Pilot Lighting Procedures, Standing Pilot Only Initial Pilot Lighting

DECATHLON SERIES GAS FRYERS (NON-CE) CHAPTER 4: FRYER OPERATIONS 4-3 4.1.2 Pilot Lighting Procedures, Electronic Ignition Systems WARNING Never

DECATHLON SERIES GAS FRYERS (NON-CE) CHAPTER 4: FRYER OPERATIONS 4-4 4.2 Boil-Out Procedure (cont.) A. Pour cleaning solution into the frypot a

DECATHLON SERIES GAS FRYERS (NON-CE) CHAPTER 4: FRYER OPERATIONS 4-5 4.2 Boil-Out Procedure (cont.) J. Close the drain, add fresh water (withou

DANGER Adequate means must be provided to limit the movement of this appliance without depending upon the gas line connection. Single fryers equipp

DECATHLON SERIES GAS FRYERS (NON-CE) CHAPTER 4: FRYER OPERATIONS 4-6 4.3.1 Filling Fryer with Shortening (cont.) D. Operating Thermostat: Turn t

DECATHLON SERIES GAS FRYERS (NON-CE) CHAPTER 5: CONTROLLER OPERATING INSTRUCTIONS 5–1 5.1 Operating Instructions: Electronic Thermostat Controller

DECATHLON SERIES GAS FRYERS (NON-CE) CHAPTER 5: CONTROLLER OPERATING INSTRUCTIONS 5–2 5.1 Operating Instructions: Electronic Thermostat Controller

DECATHLON SERIES GAS FRYERS (NON-CE) CHAPTER 5: CONTROLLER OPERATING INSTRUCTIONS 5–3 5.2 Electronic Thermostat Controller/Computer With Back-up T

THIS PAGE INTENTIONALLY LEFT BLANK.

DECATHLON SERIES GAS FRYERS (NON-CE) CHAPTER 6: PREVENTATIVE MAINTENANCE 6-1 6.1 General DANGER Never attempt to clean the fryer during the coo

DECATHLON SERIES GAS FRYERS (NON-CE) CHAPTER 6: PREVENTATIVE MAINTENANCE 6-2 6.1.3 Periodic/ Annual The fryer should be inspected and adjusted p

DECATHLON SERIES GAS FRYERS (NON-CE) CHAPTER 7: TROUBLESHOOTING 7-1 7.1 General DANGER Hot shortening will cause severe burns. Never attempt to

DECATHLON SERIES GAS FRYERS (NON-CE) CHAPTER 7: TROUBLESHOOTING 7-2 7.2 Pilot Burner Malfunction (cont.) 4. Check all connections for cleanline

DECATHLON SERIES GAS FRYERS (NON-CE) CHAPTER 7: TROUBLESHOOTING 7-3 7.3 Main Burner Malfunctions (cont.) D. Fryer will not reach the temperatur

Decathlon Series Gas Fryers Installation & Operation Manual TABLE OF CONTENTS Page # 1. INTRODUCTION 1-1 1.1 After Purchase 1-1 1.

Dean, 8700 Line Avenue, PO Box 51000, Shreveport, Louisiana 71135-1000Shipping Address: 8700 Line Av enue, Shreveport, Louisiana 71106TEL 1-318-86

Decathlon Series Gas Fryers Installation & Operation Manual TABLE OF CONTENTS (CONT.) Page # 5. CONTROLLER OPERATING INSTRUCTIONS 5

FINDING YOUR WAY AROUND THE DEAN DECATHLON 3” Round Drains (SCFD models)1.5” Round DrainsTop CapFlue CapBasket HangerFrypotDrain TubesDrain Valve Han

DECATHLON SERIES GAS FRYERS (NON-CE) CHAPTER 1: INTRODUCTION 1-1 1.1 After Purchase In order to improve service, have the following chart filled

DECATHLON SERIES GAS FRYERS (NON-CE) CHAPTER 1: INTRODUCTION 1-2 1.4 Computer Information (cont.) The user is cautioned that any changes or modi

DECATHLON SERIES GAS FRYERS (NON-CE) CHAPTER 1: INTRODUCTION 1-3 1.6 Service Personnel 1.6.1 Definitions A. Qualified and/or Authorized Opera